纱线线密度及质量不匀率自动测试装置及方法

纺织学报 ›› 2012, Vol. 33 ›› Issue (5): 131-134.

纱线线密度及质量不匀率自动测试装置及方法

周彬¹,王慧玲¹,樊理山^2，3,闵庭元⁴,王韶辉⁵

1. 盐城纺织职业技术学院纺织检测中心
2. 江苏省生态纺织工程研发中心
3. 南京大学生命科学学院
4. 盐城市纤维检验所
5. 法国国际检验局（法国BV）上海办事处

收稿日期:2011-06-20 修回日期:2012-02-13 出版日期:2012-05-15 发布日期:2012-05-15
通讯作者: 周彬 E-mail:sanlinbaby@126.com

Automatic test device and test method for yarn linear density and weight eveness

ZHOU Bin,¹ WANG Hui-Ling¹, FAN Li-Shan^2，3, MIN Ting-Yuan⁴, WANG Shao-Hui⁵

1. Textile Testing Center,Yancheng Textile Vocational Technology College
2. Ecikigucak Textile Engineering R & D Center
3. Life Science Institute, Nanjing University
4. Yancheng Fiber Testing Institution
5. Shanghai Offiee, Bureau Veritas Consumer Products Services

Received:2011-06-20 Revised:2012-02-13 Online:2012-05-15 Published:2012-05-15

摘要/Abstract

摘要： 针对现有纱线线密度测试装置所存在的缺陷，研制了纱线线密度及重量不匀率自动测试装置。此装置主要包括电子称重、弹簧线性加压、电子计长、变频卷绕及控制等部分。参照GB/T 4743-2009，设置试验长度及预加张力，介绍了利用该装置进行纱线线密度及重量不匀率测试的程序和方法。以T/R65/35筒子纱为例，采用此装置与传统缕纱测长机进行线密度对比试验，实践证明：此装置测试结果准确度达99.7%，而传统缕纱测长机测试结果准确度仅为95%，在线密度及重量不匀率测试中保证纱线连续无废纱产生，且测试方便，体积小，具有较高的应用及推广价值。

关键词: 纱线 , 线密度 , 质量不匀率 , 测试装置

Abstract: Aiming at the defects which exist in present yarn linear density test device, an automatic test device about yarn linear density and weight eveness was developed. This device included electronic balance, spring linear pressure, electronic calculation length , frequency conversion winding and controller. Test length and advanced tension were set refering to GB/T 4743 2009, test procedures and methods about linear density and weight eveness were introduced using this device. A linear density contrast test was done taking T/R65/35 bobbin yarns as example, practice showed: its accuracy of the test results was 99.7%, while the test results accuracy using traditional device was only 95%. and test process was convenient, yarn was continuous without waste yarn, it also had smaller volume, so it had higher application and promotion value.

Key words: yarn , linear density , weight eveness , test device

中图分类号:

TS107.2

周彬, 王慧玲, 樊理山, 闵庭元, 王韶辉. 纱线线密度及质量不匀率自动测试装置及方法[J]. 纺织学报, 2012, 33(5): 131-134.

ZHOU Bin, WANG Hui-Ling, FAN Li-Shan, MIN Ting-Yuan, WANG Shao-Hui. Automatic test device and test method for yarn linear density and weight eveness[J]. JOURNAL OF TEXTILE RESEARCH, 2012, 33(5): 131-134.

参考文献

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

[1]	张才前, 王春艳, 刘成霞. 束缚态下服装面料的保型规律[J]. 纺织学报, 2012, 33(3): 44-47.
[2]	张如全;周双喜;;陶荣;林建勇. 基于单片机织物动态热传递性能测试装置[J]. 纺织学报, 2011, 32(3): 122-126.
[3]	刘红;陈东生;魏取福. 服装压力对人体生理的影响及其客观测试[J]. 纺织学报, 2010, 31(3): 138-142.
[4]	代雪梅;王保中;顾平. 浮力测试装置的开发[J]. 纺织学报, 2007, 28(5): 122-124.
[5]	毕鹏宇;陈跃华;李汝勤. 振动型负离子测试装置与测试方法探讨[J]. 纺织学报, 2004, 25(05): 115-116.