纺织学报 ›› 2013, Vol. 34 ›› Issue (7): 95-99.

• 服装工程 • 上一篇    下一篇

缝制条件下织物的弯曲和悬垂性能

杨允出1,2,刘旖婧2,丁笑君1,2   

    1. 浙江理工大学浙江省服装工程研究中心
    2. 浙江理工大学服装学院
  • 收稿日期:2012-08-02 修回日期:2013-01-22 出版日期:2013-07-15 发布日期:2013-07-15
  • 通讯作者: 杨允出 E-mail:gary0577@126.com

Analysis of bending and drape properties of seamed fabrics

  • Received:2012-08-02 Revised:2013-01-22 Online:2013-07-15 Published:2013-07-15
  • Supported by:

    浙江省自然科学基金项目;浙江省服装工程技术研究中心开放基金项目

摘要: 本文首先调查分析不同类型缝份部位整体弯曲性能的变化,然后着重研究在不同接缝位置、不同缝型和不同缝份宽度条件下有缝织物的悬垂性能变化及其原因。结果显示:缝份部位的抗弯长度和抗弯刚度与原织物相比有明显增加;有缝织物的悬垂系数、平均半径、硬挺系数等指标均大于无缝织物;一般缝份宽度增加,悬垂系数有稍微增大趋势;接缝的位置对悬垂性的影响与织物经纬向性能有关;抗弯长度大的缝型一般比抗弯长度小的缝型对悬垂系数影响大;试样边缘缝份会导致圆周方向的抗弯性能提高,从而使悬垂系数增加。该研究将对缝制后面料及服装造型评价及模拟具有一定的实践指导意义。

关键词: 缝份, 织物, 弯曲性能, 悬垂性能

Abstract: Firstly, this paper investigated the bending performance of the different seams. Then, the fabrics’ drape performance with different sewing conditions and its influencing factors were discussed as a focus based on the seam’s bending performance. The results show as follows:(1) The seams’ bending length and bending rigidity are obviously increase compared with the original fabric; (2) Some main drape parameters of the samples with seam (drape coefficient, average radius, stiffness index) are greater than un-sewn fabric; (3) For most samples, the wider seam allowance is, the bigger drape coefficient is; (4) The influence of the seam position on the drape coefficient is related to the fabric’s mechanical properties in the warp and weft direction; (5)Generally, the seams with higher bending length have more influence on the fabric’s drape coefficient than the seams with lower bending length; (6)The circular edge seams can increase the bending rigidity and the drape coefficient. The study has some helps for fabric and garment drape evaluation and can contribute to the further research on fabric or garment simulation after considering the seam performance.

Key words: seam, fabric, bending property, draping property

中图分类号: 

  • TS
[1] 李冻 陈太球 蒋春燕 傅佳佳 王鸿博. 原料及结构参数对防电弧织物性能的影响[J]. 纺织学报, 2018, 39(08): 41-45.
[2] 汪珊娜 张华熊 康锋. 基于卷积神经网络的领带花型情感分类[J]. 纺织学报, 2018, 39(08): 117-123.
[3] 杨文权 蒋金华 陈南梁. 玻璃纤维织物在剪切变形作用下的渗透率[J]. 纺织学报, 2018, 39(08): 58-62.
[4] 敖利民 唐雯. 基于综框任意升降的随机织物设计方法[J]. 纺织学报, 2018, 39(08): 33-40.
[5] 陈萌 朱方龙 . 热辐射下织物内水分干燥实验及其动力学研究[J]. 纺织学报, 2018, 39(08): 52-57.
[6] 翟胜男 陈太球 蒋春燕 傅佳佳 王鸿博. 消防服外层织物热防护性与舒适性综合评价[J]. 纺织学报, 2018, 39(08): 100-104.
[7] 周存 何雅僖. 超疏水导电聚酯织物的制备及其性能[J]. 纺织学报, 2018, 39(08): 88-94.
[8] 辛春莉 王子玉 周建 潘如如 高卫东. 数码相机在染色织物色差测量中的应用[J]. 纺织学报, 2018, 39(08): 77-82.
[9] 秦传香 鲍志敏 戴礼兴 梅锋. 新型萘酰亚胺类荧光染料的合成及其染色应用[J]. 纺织学报, 2018, 39(07): 74-81.
[10] 张永革 王慧玲 周彬 陈燕. 自体涂层双重防护服用织物的开发[J]. 纺织学报, 2018, 39(07): 39-43.
[11] 王嘉欣 田秀枝 蒋学 王鸿博 高卫东. 二醛 β-环糊精/壳聚糖改性对涤纶织物亲水性能的影响[J]. 纺织学报, 2018, 39(07): 82-88.
[12] 肖慧芳 阎克路 纪柏林. 糖类添加剂在1,2,3,4-丁烷四羧酸棉织物防皱整理中的应用[J]. 纺织学报, 2018, 39(07): 89-94.
[13] 刘成霞 周澳. 利用十字交叉法测试织物弯曲悬垂性[J]. 纺织学报, 2018, 39(06): 42-46.
[14] 高树珍 迟文锐 王兵兵 汪亮. 磷-氮耐氯阻燃整理剂的合成及其应用[J]. 纺织学报, 2018, 39(06): 101-105.
[15] 马晓红 檀江涛 秦志刚. 碳纤维二维编织管状织物的编织工艺[J]. 纺织学报, 2018, 39(06): 64-69.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!