基于布面毛羽特征参数测试的织物抗起毛性客观评价

纺织学报 ›› 2013, Vol. 34 ›› Issue (4): 57-63.

基于布面毛羽特征参数测试的织物抗起毛性客观评价

张林彦¹,敖利民²,郁崇文³

1. 河北科技大学纺织服装学院
2. 嘉兴学院材料与纺织工程学院
3. 东华大学纺织学院

收稿日期:2012-04-26 修回日期:2013-01-10 出版日期:2013-04-15 发布日期:2013-04-09
通讯作者: 敖利民 E-mail:aolimin@126.com
基金资助:
现代农业产业技术体系建设专项资金资助项目；河北省纺织服装工程技术研究中心开放课题基金项目

Objective evaluation on fuzz resistance of fabric based on testing of characteristic parameters of fabric hairiness

Received:2012-04-26 Revised:2013-01-10 Online:2013-04-15 Published:2013-04-09
Contact: Li-Min AO E-mail:aolimin@126.com
Supported by:
Earmarked Fund for Modern Agro-industry Technology Research System

摘要/Abstract

摘要： 利用织物单面压缩测试装置测试了布面毛羽各特征指标随起毛次数的变化规律，提出了客观评价织物抗起毛性的方法。研究表明：布面毛羽各特征指标均随着起毛次数的增加而增大，但在起毛次数较小时，随起毛次数增加显著，随着起毛的继续增加，各指标趋于稳定而变化不显著；织物抗起毛性可采用一定起毛次数（20次）后测得的布面毛羽各指标相对于织物原样布面毛羽各指标的变化率进行评价；在毛羽长度变化率、分界压力变化率、压缩功变化率和压缩比功变化率四个指标中，以毛羽长度变化率为第一判据，同时，起毛处理后毛羽长度的绝对值可以作为毛羽长度变化率相仿时的参考指标。

关键词: 抗起毛性, 布面毛羽, 特征指标, 毛羽长度变化率客观评价

Abstract: Characteristic indexes variation of fabric hairiness with fuzzing numbe are tested using the fabric sigle-sided compressing tester, the objective evaluation measurement for fuzz resistance of fabric is proposed. Studies have shown that: characteristic indexes of fabric hairiness raise along with fuzzing number increses, but they raise greatly when the fuzzing number is small and tend to be stable along with continue increasing of fuzzing number; the fuzz resistance of fabric can be evaluated using the rates of change of characteristic indexes of fabric hairiness after certain times (20 times) of fuzzing relative to the the original sample; among the 4 indicators of changing rate of hairiness length, changing rate of cut-off point presure, changing rate of comressing work and changing rate of compressing specific work, the changing rate of hairiness length is the determine criterion, at the same time, the hairiness length of fabric after fuzzing can be used as a reference indicator when the changing rates of hairiness length are almost the same.

Key words: fuzz resistance, fabric hairiness, characteristic index, hairiness length change rate, objective evaluation

中图分类号:

TS 101．91

张林彦敖利民郁崇文. 基于布面毛羽特征参数测试的织物抗起毛性客观评价[J]. 纺织学报, 2013, 34(4): 57-63.

参考文献

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

[1]	敖利民郁崇文李春钢. 基于布面毛羽特征变化的织物烧毛效果评价[J]. 纺织学报, 2015, 36(04): 102-0.
[2]	尹玲张文斌许才国. 基于有序样本最优分割法的女性体型分类[J]. 纺织学报, 2014, 35(9): 114-0.
[3]	陶晨. 混纺纱截面图像分析中的光斑扩散模型[J]. 纺织学报, 2009, 30(04): 45-49.
[4]	阎玉秀;朱江晖;陶建伟. 女套装上衣结构特征指标及其数学模型[J]. 纺织学报, 2008, 29(8): 85-89.