纺织学报 ›› 2013, Vol. 34 ›› Issue (7): 35-39.

• 纺织工程 • 上一篇    下一篇

梳棉机盖板踵趾差对纱线毛羽的影响

于学智,曹继鹏,孙鹏子   

  1. 辽东学院
  • 收稿日期:2012-07-10 修回日期:2012-11-29 出版日期:2013-07-15 发布日期:2013-07-15
  • 通讯作者: 孙鹏子 E-mail:kyc3@163.com
  • 基金资助:

    辽宁省高等学校重点学科资助项目, 辽宁教育厅科研项目

Influence of flat heel-toe difference of carding machine on yarn hairiness

1,Ji-Peng CAO   

  • Received:2012-07-10 Revised:2012-11-29 Online:2013-07-15 Published:2013-07-15

摘要: 研究了梳棉机踵趾差变化对成纱毛羽数量的影响问题。用YG172型纱线毛羽仪对四档盖板踵趾差、两档锡林速度和三档梳棉机产量共24种生产方案所加工的纱线的毛羽进行了检测。用SPSS软件对检测结果进行分析,发现踵趾差对纱线毛羽指标影响显著,当锡林采用394r/min时,总体上以踵趾差采用0.42mm所加工的纱线毛羽为最少;当锡林采用296r/min时,所有方案以踵趾差采用0.56mm所加工的纱线毛羽为最少。在所有试验方案中总体上以0.56mm和0.42mm两档踵趾差有利于毛羽的减少;以 0.14mm踵趾差所加工的纱线毛羽为最多,说明过小踵趾差不利于毛羽的减少。

关键词: 梳棉机, 盖板踵趾差, 锡林速度, 道夫速度, 纱线毛羽

Abstract: Effect of carding machine heel-toe difference on yarn hairiness number is studied. The hairiness of yarns processed by 24 plans under four-grade flat heel-toe difference, two-grade cylinder speed and three-grade carding output was tested by YG172 yarn hairiness tester. The test results were analyzed by SPSS software. The results show that heel-toe difference has notable influence on yarn hairiness index. When cylinder speed is 394r/min, the yarn hairiness is the least under 0.42mm heel-toe difference; while cylinder speed is 296r/min,the yarn hairiness is the least under 0.56mm heel-toe difference. In all test plans, the heel-toe difference of 0.56mm and 0.42mm are beneficial to hairiness reduction as a whole;the yarn hairiness is the most under 0.14mm heel-toe difference, which shows that too small heel-toe difference is not conducive to hairiness reduction.

Key words: carding machine, heel-toe difference, cylinder speed, doffer speed, yarn hairiness

中图分类号: 

  • 103.11
[1] 王盼 程隆棣 华志宏. 刺辊锯齿螺旋倾角与分梳质量关系的理论研究[J]. 纺织学报, 2017, 38(09): 131-135.
[2] 孙银银 张宁 吴洋 潘如如 高卫东. 纱线毛羽骨架及长度的跟踪测量[J]. 纺织学报, 2017, 38(08): 32-38.
[3] 李新龙 马崇启 周宝明. 数字式梳棉机自调匀整控制系统开发[J]. 纺织学报, 2015, 36(08): 139-143.
[4] 曹继鹏 张志丹 孙鹏子. 锡林速度对盖板花纤维长度分布的影响[J]. 纺织学报, 2015, 36(03): 24-0.
[5] 张明光;孙鹏子;曹继鹏. 梳棉机盖板速度对盖板花纤维长度分布的影响[J]. 纺织学报, 2011, 32(3): 47-50.
[6] 曹继鹏;王瑞;孙鹏子. 静电板电压和隔距对生条棉结的影响[J]. 纺织学报, 2010, 31(2): 101-105.
[7] 牟俊玲;邱华;葛明桥. 旋流器对环锭纺纱线性能的影响[J]. 纺织学报, 2009, 30(11): 43-47.
[8] 周国庆;蒋秀明;张建业;郑筱春;郭东亮;徐国胜. 高产梳棉机活动盖板悬垂问题的研究[J]. 纺织学报, 2009, 30(08): 128-133.
[9] 孙鹏子;曹继鹏. 全固定盖板梳棉机的研究进展[J]. 纺织学报, 2009, 30(05): 137-141.
[10] 李银星. 梳棉机运行状态的可拓判定研究[J]. 纺织学报, 2008, 29(6): 130-134.
[11] 张明光;孙鹏子. 不同型式棉网清洁器的对比研究[J]. 纺织学报, 2008, 29(4): 111-114.
[12] 邵敬党. 梳棉机后罩板处附加分梳装置的理论探讨[J]. 纺织学报, 2007, 28(6): 115-117.
[13] 褚结;葛明桥. 旋流器降低环锭纺纱线毛羽的研究[J]. 纺织学报, 2007, 28(12): 34-37.
[14] 钱友三;程隆棣;薛文良. 络筒上蜡装置设计原理与分析[J]. 纺织学报, 2007, 28(1): 102-104.
[15] 孙鹏子;王兰;张志丹;张明光. 梳棉机刺辊落棉和盖板花纤维长度分布[J]. 纺织学报, 2006, 27(5): 80-83.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!