一色齿毛菌对直接大红4BS染料的脱色

doi:10.13475/j.fzxb.20180904606

纺织学报 ›› 2020, Vol. 41 ›› Issue (04): 78-83.doi: 10.13475/j.fzxb.20180904606

一色齿毛菌对直接大红4BS染料的脱色

徐红云¹, 于存²(), 苏帮¹

1.贵州民族大学生态环境工程学院, 贵州贵阳 550025
2.贵州大学林学院, 贵州贵阳 550025

收稿日期:2018-09-18 修回日期:2020-01-19 出版日期:2020-04-15 发布日期:2020-04-27
通讯作者: 于存
作者简介:徐红云(1988—),女,讲师,博士。主要研究方向为环境工程微生物。
基金资助:
贵州民族大学自然科学类基金项目(0703001018002032)

Optimization of decolorization conditions of Direct Scarlet 4BS by Cerrena unicolor

XU Hongyun¹, YU Cun²(), SU Bang¹

1. College of Eco-Environment Engineering, Guizhou Minzu University, Guiyang, Guizhou 550025, China
2. College of Forestry, Guizhou University, Guiyang, Guizhou 550025, China

Received:2018-09-18 Revised:2020-01-19 Online:2020-04-15 Published:2020-04-27
Contact: YU Cun

摘要/Abstract

摘要：

为避免染料废水处理造成二次污染,采用生物法对直接染料进行脱色处理,通过观察接种一色齿毛菌后染料固体培养基颜色的变化,评价一色齿毛菌对5种直接染料的脱色效果;利用单因素和正交试验对一色齿毛菌脱色直接大红4BS的条件进行优化,得到优化条件:葡萄糖质量浓度为20 g/L,硝酸铵质量浓度为1 g/L,硫酸镁浓度为1.5 mmol/L,每50 mL反应体系接菌量为2片(直径为1 cm)。结果表明:一色齿毛菌对5种直接染料均有脱色能力,其中对直接大红4BS染料的脱色更为彻底;在优化条件下,一色齿毛菌对直接大红4BS脱色13 d时的脱色率达92.00%, 与优化前的脱色率相比提高了50.82%。

关键词: 一色齿毛菌, 直接染料, 直接大红4BS, 脱色, 染料废水

Abstract:

Aiming to avoid secondary pollution in treating dyeing wastewater and to clarify the decolorization ability of Cerrena unicolor to direct dyes, the decolorization effect of 5 direct dyes under solid condition was detected by Cerrena unicolor. Meanwhile, the decolorization conditions of Direct Scarlet 4BS by Cerrena unicolor were optimized. The results show that 5 direct dyes can be decolorized by Cerrena unicolor, among which, the decolorization performance of Direct Scarlet 4BS is the most obvious. The optimized decolorization conditions of Direct Scarlet 4BS dye by Cerrena unicolor are found as follows: glucose 20 g/L, ammonium nitrate 1 g/L, MgSO₄ 1.5 mmol/L, and inoculation amount is 2 pieces (diameter 1 cm)/50 mL reaction system. Under optimized conditions, the decolorization rate of Direct Scarlet 4BS by Cerrena unicolor is 92.00% at 13 d. Compared with the decolorization rate before optimization, the decolorization rate is increased by 50.82%.

Key words: Cerrena unicolor, direct dye, Direct Scarlet 4BS, decolorization, dyeing wastewater

中图分类号:

X791

徐红云, 于存, 苏帮. 一色齿毛菌对直接大红4BS染料的脱色[J]. 纺织学报, 2020, 41(04): 78-83.

XU Hongyun, YU Cun, SU Bang. Optimization of decolorization conditions of Direct Scarlet 4BS by Cerrena unicolor[J]. Journal of Textile Research, 2020, 41(04): 78-83.

图/表 9

表1

图1

图2

图3

图4

图5

图6

表2

图7

参考文献 15

[1]	邢黎明, 侯红敏. 纺织印染废水脱色方法研究[J]. 黑龙江环境通报, 2002,26(1):52-53.
	XING Liming, HOU Hongmin. Study on decolorization of textile printing and dyeing wastewater[J]. Heilongjiang Environmental Journal, 2002,26(1):52-53.
[2]	王趁红. 纺织废水脱色、COD值降低的生物处理技术的改进:I[J]. 染整技术, 2001,23(1):46.
	WANG Chenhong. Improvement of biological treatment technology for decolorization of textile wastewater and reduction of COD value:I[J]. Textile Dyeing and Finishing Journal, 2001,23(1):46.
[3]	陶金, 张德锁, 林红, 等. 介孔氧化硅/棉复合纤维对染料的吸附性能[J]. 纺织学报, 2018,39(10):93-97.
	TAO Jin, ZHANG Desuo, LIN Hong, et al. Adsorption properties of cotton fiber functionalized by mesoporous nanoparticle for dyes[J]. Journal of Textile Research, 2018,39(10):93-97.
[4]	吴海培, 高晓红, 方婧, 等. 二氧化钛/还原氧化石墨烯复合材料的制备及其光催化降解脱色性能[J]. 纺织学报, 2018,39(12):78-83.
	WU Haipei, GAO Xiaohong, FANG Jing, et al. Preparation and photocatalytic degradation decoloring of TiO₂/reduced graphene oxide composites[J]. Journal of Textile Research, 2018,39(12):78-83.
[5]	郑苗苗, 邵淑丽, 张东向, 等. 红平菇漆酶基因异源表达及对染料脱色的研究[J]. 纺织学报, 2014,35(12):84-90.
	ZHENG Miaomiao, SHAO Shuli, ZHANG Dongxiang, et al. Heterologous expression of pleurotus djamor laccase gene in pichia pastoris and decolorization on dyes by recombinant laccase[J]. Journal of Textile Research, 2014,35(12):84-90.
[6]	陈文华, 李刚, 许方程, 等. 染料废水污染现状及处理方法研究进展[J]. 浙江农业科学, 2014,1(2):264-269.
	CHEN Wenhua, LI Gang, XU Fangcheng, et al. Research progress on pollution and treatment of dye wastewater[J]. Journal of Zhejiang Agricultural Sciences, 2014,1(2):264-269.
[7]	FU Y, VIRARAGHAVAN T. Fungal decolorization of dye wastewaters: a review[J]. Bioresour Technol, 2001,79(3):251-262.
[8]	司静, 崔宝凯, 李牧洁. 东方栓孔菌菌丝体生物吸附剂对染料的脱色作用及其吸附机制研究[J]. 菌物学报, 2012,31(6):890-899.
	SI Jing, CUI Baokai, LI Mujie. Dye decolorization by adsorbents obtained from trametes orientalis mycelia and investigation of the adsorptive mechanism[J]. Mycosystema, 2012,31(6):890-899.
[9]	SEN S K, RAUT S, BANDYOPADHYAY P, et al. Fungal decolouration and degradation of azo dyes: a review[J]. Fungal Biology Reviews, 2016,30(3):112-133.
[10]	于存, 池玉杰. 一色齿毛菌产MnP的条件优化及对染料的脱色[J]. 林业科学, 2014,50(7):121-127.
	YU Cun, CHI Yujie. Optimization of culture conditions of MnP produced by Cerrena unicolor and its decolorization to 5 kinds of dyes[J]. Scientia Silvae Sinicae, 2014,50(7):121-127.
[11]	刘桂萍, 王鲁萍, 王瑾, 等. 开放体系下霉菌7对偶氮染料的吸附降解[J]. 纺织学报, 2012,33(3):67-73.
	LIU Guiping, WANG Luping, WANG Jin, et al. Adsorption and degradation of azo-dye by mold 7 under open system[J]. Journal of Textile Research, 2012,33(3):67-73.
[12]	于存, 池玉杰. 一色齿毛菌对活性染料的脱色研究[J]. 北京林业大学学报, 2014,36(4):126-132.
	YU Cun, CHI Yujie. Decolorization to two reactive dyes of Cerrena unicolor CB1[J]. Journal of Beijing Forestey University, 2014,36(4):126-132.
[13]	袁海生, 戴玉成, 曹云, 等. 白腐真菌染料脱色菌株的筛选及一色齿毛菌脱色条件的研究[J]. 菌物学报, 2010,29(3):429-436.
	YUAN Haisheng, DAI Yucheng, CAO Yun, et al. Screening of white rot fungi for decolorizing synthetic dyes and investigation on factors affecting decolorizing capacity of Cerrena unicolor[J]. Mycosystema, 2010,29(3):429-436.
[14]	王慧, 郑小伟, 王宾香, 等. 真菌对染料的脱色研究进展[J]. 应用与环境生物学报, 2009,15(1):147-151.
	WANG Hui, ZHENG Xiaowei, WANG Binxiang, et al. Advance in decolorization of dye by fungi[J]. Journal of Applied and Environmental Biology, 2009,15(1):147-151.
[15]	程勇前, 黄民生, 张国营. 白腐真菌对染料脱色及降解过程机理和影响因素[J]. 环境污染治理技术与设备, 2000,1(6):25-33.
	CHENG Yongqian, HUANG Minsheng, ZHANG Guoying. Decoloration and degradation of dyes by white rot fungi[J]. Techniques and Equipment for Environmental Pollution Control, 2000,1(6):25-33.

相关文章 15

[1]	钱怡帆, 周堂, 张礼颖, 刘万双, 凤权. 聚丙烯腈/ 醋酸纤维素/ TiO₂ 复合纳米纤维膜的制备及其光催化降解性能[J]. 纺织学报, 2020, 41(05): 8-14.
[2]	庄帅, 阳海, 安继斌, 胡倩, 张浩, 贺贵添, 易兵. 硫酸根自由基对酸性红37的降解动力学与机制[J]. 纺织学报, 2019, 40(11): 131-139.
[3]	郭东艳, 徐乃库, 肖长发. 内涂覆锰氧化物聚(甲基)丙烯酸酯中空纤维制备及其对亚甲基蓝的脱色性能[J]. 纺织学报, 2019, 40(10): 26-32.
[4]	陈欣, 张家琳, 王纪冬, 李晓强, 葛明桥. 电絮凝技术在废弃涤纶醇解液脱色中的应用[J]. 纺织学报, 2019, 40(10): 98-104.
[5]	韩健健, 胡勇杰, 胡敏专. 基于纳滤技术的质检萃取液脱色预处理方法[J]. 纺织学报, 2019, 40(09): 136-142.
[6]	孙慧萍, 吕文洲. 膨润土负载锌-钴催化臭氧处理模拟染料废水[J]. 纺织学报, 2019, 40(03): 118-124.
[7]	李庆, 樊增禄, 张洛红, 李勇, 陈创勋. 锆-有机骨架对水中染料的高选择性可循环吸附[J]. 纺织学报, 2019, 40(02): 141-146.
[8]	吴海培高晓红方婧刘其霞何平. 二氧化钛/还原氧化石墨烯复合材料的制备及其光催化降解脱色性能[J]. 纺织学报, 2018, 39(12): 78-83.
[9]	魏亮陈小光黄波唐丽娟王玉. 偶氮染料废水厌氧生物脱色强化[J]. 纺织学报, 2018, 39(08): 83-87.
[10]	李庆张莹樊增禄朱炜. Cu-有机骨架对染料废水的吸附和可见光降解[J]. 纺织学报, 2018, 39(02): 112-118.
[11]	刘婵谢春萍刘新金杨艳春李蔚. 亚铁离子质量浓度对黑牦牛绒纤维脱色的影响[J]. 纺织学报, 2016, 37(4): 21-26.
[12]	徐万福傅伟松周乃锋陈华祥丁亚钢 . 分散染料自动连续化生产新工艺[J]. 纺织学报, 2016, 37(11): 80-85.
[13]	刘婵谢春萍刘新金曲华洋徐伯俊. 黑牦牛绒氧化脱色工艺优化及其可纺性[J]. 纺织学报, 2016, 37(07): 49-54.
[14]	何华玲张健飞于志财路艳华林杰. 阳离子淀粉-膨润土复合絮凝剂对活性染料的吸附[J]. 纺织学报, 2014, 35(7): 101-0.
[15]	吴宝宅武志云汪少朋甘胜华. 应用二甲基亚砜对废旧聚酯纺织品的脱色[J]. 纺织学报, 2014, 35(4): 84-0.

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

水平	A 葡萄糖质量浓度/ (g·L^-1)
1	15	0.5	0.5	2
2	20	1.0	1.0	4
3	25	1.5	1.5	6

试验编号	葡萄糖质量浓度/ (g·L^-1)	硫酸铵质量浓度/ (g·L^-1)	硫酸镁浓度/ (mmo·L^-1)	接菌量 (直径为 1 cm)/片	脱色率/%
1	15	0.5	0.5	2	88.25
2	15	1.0	1.0	4	77.67
3	15	1.5	1.5	6	85.54
4	20	0.5	1.0	6	74.37
5	20	1.0	1.5	2	89.12
6	20	1.5	0.5	4	75.98
7	25	0.5	1.5	4	78.28
8	25	1.0	0.5	6	82.40
9	25	1.5	1.0	2	79.89
K₁	79.82	80.07	82.21	85.75
K₂	83.83	86.59	77.31	77.31
K₃	80.19	80.47	85.68	81.31
R	4.01	6.12	7.37	8.44
最优水平	20	1.0	1.5	2

一色齿毛菌对直接大红4BS染料的脱色

Optimization of decolorization conditions of Direct Scarlet 4BS by Cerrena unicolor

RichHTML

PDF (PC)

摘要/Abstract

引用本文

使用本文

图/表 9

参考文献 15

相关文章 15

Metrics

本文评价

推荐阅读 0